Product ID:FLAW-FINDER AG-1-DH DEVELOPER
MSDS Date:03/25/1994
FSC:6850
NIIN:00-145-0255
Kit Part:Y
MSDS Number: BTSCR

Emergency Phone: 201-767-7300

Info Phone: 800-526-1008

Cage: 03530

Telephone: 201-767-7300

Cage: 03530

TRADE SECRET COMPONENT

Fraction By Weight: 90% %

OSHA PEL 500 PPM

ACGIH TLV: 500 PPM

NON HAZARDOUS INGREDIENTS

Fraction By Weight: 10 - 20%

LD50 LC50 Mixture:NOT GIVEN FOR PRODUCT AS A WHOLE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:MAY BE IRRITATING TO THE EYES.
PROLONGED OR REPEATED SKIN CNONTACT TENDS TO REMOVE SKIN OILS
POSSIBLY LEADING TO IRRITATION AND DERMATITIS. VAPORS MAY IRRITATE
THE NOSE, THROAT AND UPPER RESPIRATORY T RACT. VAPORS ARE
ANESTHETIC AND MAY HAVEOTHER CENTRAL NERVOUS SYSTEM EFFECTS.
INGESTION MAY CAUSE GI DISTURBANCES.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION, UPPER
RESPIRATORY TRACT IRRITATION, HEADACHES, DIZZINESS, NAUSEA,
VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING HEART
DISEASE MAY BE AT INCREASED RISK FROM EXPOSURE.

First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION. IN HALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. GET MEDICAL
ATTENTION.

Flash Point:NONFLAMMABLE
Lower Limits:7.4 %
Upper Limits:15.5 %
Extinguishing Media:FOAM, WATER FOG, DRY CHEMICAL, CARBON DIOXIDE
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:DO NOT USE DIRECT STREAM OF WATER ON
FIRE. TOXIC GASES ARE RELEASED DURING COMBUSTION.

Spill Release Procedures:CONTAIN SPILL. STOP LEAK IF CAN DO SO WITHOUT
RISK. REMOVE ALL SOURCES OF IGNITION. ABSORB LIQUID WITH SUITABLE
ABSORBENT MATERIAL. COLLECT FOR DISPOSAL. KEEP MATERIAL OUT OF
SEWERS AND WATER COURSES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES. KEEP CONTAINERS CLOSED AND PLAINLY LABELED.
Other Precautions:AVOID SKIN CONTACT. LAUNDER CONTAMINATED CLOTHING
BEFORE REUSE. AVOID TEMPERATURES IN EXCESS OF 120F. DO NOT PUNCTURE
OR INCINERATE CANS.

Respiratory Protection:NOT NORMALLY REQUIRED.
Ventilation:PROVIDE GREATER THAN 60 FEET PER MINUTE HOOD FACE VELOCITY.
USE EXPLOSION PROOF EQUIPMENT.
Protective Gloves:CHEMICAL RESISTANT OTHER THAN RUBBER
Eye Protection:SAFETY GLASSES OR GOGGLES
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO AVOID
SKIN CONTACT. AN EMERGENCY EYE WASH STATION AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
KEY1:J7. THIS PRODUCT IS A KIT CONSISTING OF THREE PARTS.
CLEANER/REMOVER HAS PNI L, DEVELOPER HAS PNI K AND PENETRANT HAS
PNI H, SAME NSN. FORMULA CHANGED. FOR PREVIOUS FORMULATIONS, SEE
PNI A, B, C, D, E, F, G, I AND J, SAME NSN.

HCC:V2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=32.C, 89.5F
Vapor Pres:517
Vapor Density:4.0
Spec Gravity:1.36
Evaporation Rate & Reference:>1 (WATER = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:MILKY LIQUID, CITRUS ODOR
Percent Volatiles by Volume:90 %

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ALKALIS OR ALKALINE EARTH METALS
Stability Condition to Avoid:HEAT, OPEN FLAME
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
HYDROGEN CHLORIDE, HYDROGEN FLUORIDE, CHLORINE

Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.